Схема SRS AirBag Lexus CT200H [Европа] 2010 год
Front Seat Airbag Assembly RH Airbag Sensor Assembly Front Seat Outer Belt Assembly RH Curtain Shield Airbag Assembly LH Junction Connector ECM Telematics Transceiver Front Seat Airbag Assembly LH Lower No. 2 Instrument Panel Airbag Assembly Rear Side Airbag Sensor Assembly LH Rear Side Airbag Sensor Assembly RH Front Airbag Sensor LH Airbag Cut Off Switch Cylinder Sub-Assembly Junction Connector Rear Seat Outer Belt Assembly LH Power Management Control ECU Spiral Cable Sub-Assembly , Driver Side Squib Circuit (Horn Button Assembly) Instrument Panel Passenger Airbag Assembly Junction Connector Combination Switch Assembly Lower No. 1 Instrument Panel Airbag Assembly Front Seat Inner Belt Assembly LH Combination Meter Assembly Junction Connector Rear Seat Outer Belt Assembly RH Junction Connector Spiral Cable Sub-Assembly , Driver Side Squib Circuit (Horn Button Assembly) Junction Connector Front Seat Inner Belt Assembly RH Junction Connector Front Seat Outer Belt Assembly LH Curtain Shield Airbag Assembly RH Front Airbag Sensor RH Junction Connector Junction Connector Front Side Airbag Sensor Assembly RH Front Side Airbag Sensor Assembly LH d=" M 1589.23, 409.43 L 1589.23, 511.42
d=" M 1589.23, 308.30 L 1589.23, 394.42
d=" M 1674.22, 409.43 L 1674.22, 511.42
d=" M 1674.22, 308.30 L 1674.22, 394.42
d=" M 2218.13, 477.14 L 2218.13, 443.71 L 2286.12, 443.71 L 2286.12, 426.71 L 2303.12, 409.72 L 2303.12, 401.78
d=" M 2303.12, 401.78 L 2303.12, 477.14
d=" M 2456.09, 477.14 L 2456.09, 443.71 L 2524.08, 443.71 L 2524.08, 426.71 L 2541.08, 409.72 L 2541.08, 401.78
d=" M 2541.08, 401.78 L 2541.08, 485.64
HH2 HH2 HG1 HG1 AH6 AH6 AH4 HQ1 AH4 HG1 HG1 H2 H4 H4 * * * If the following parts have been dropped, or have cracks, dents and other defects in their case, bracket, and connector, replace with new one. For the purpose of reuse, never disassemble and repair the following parts. Even in cases of a minor collision where the SRS does not deploy, the following parts should be inspected; * Never use SRS parts from another vehicle. When replacing parts, replace with new parts. If the vehicle is equipped with a mobile communication system, refer to the precaution in the IN section of the Repair Manual. After work on the SRS is completed, check the SRS warning light. Information labels are attached to the periphery of the SRS components. Follow the instructions of the notice. * Use a volt/ohmmeter with high impedance (10 kΩ/V minimum) for troubleshooting electrical circuits of the system. However, it is not possible to make a record of these memory contents. So when the work is finished, it will be necessary to explain it to your customer, and ask the customer to adjust the features and reset the memory. * * * Work must be started more than 90 seconds after the power switch is pushed to the "OFF" position and the negative (-) terminal cable is disconnected from the battery. When the negative (-) terminal cable is disconnected from the battery, the memory of the clock and audio system will be cleared. So before starting work, make a record of the contents in the audio memory system. * Steering wheel pad * Side airbag assembly * Front passenger airbag assembly * Curtain shield airbag assembly * Seat belt pretensioner * Center airbag sensor assembly * Front airbag sensor assembly * Rear airbag sensor assembly * Knee airbag assembly * Side airbag sensor assembly When work is finished, reset the audio systems as they were before and adjust the clock. Some vehicles have power tilt steering, power telescopic steering, power seat and power outside rear view mirror which are all equipped with memory function. * Before repair, remove the airbag sensor if shocks are likely to be applied to the sensor during repair. NOTICE : When inspecting or repairing the SRS, perform service in accordance with the following precautionary instructions and the procedure, and precautions in the Repair Manual applicable for the model year. Malfunction symptoms of the SRS are difficult to confirm, so the DTCs become the most important source of information when troubleshooting. When troubleshooting the SRS, always inspect the DTCs before disconnecting the battery. * * * (The SRS is equipped with a back-up power source so that if work is started within 90 seconds from disconnecting the negative (-) terminal cable of the battery, the SRS may deploy.) To avoid erasing the memory in each system, never use a back-up power supply from outside the vehicle. * Do not expose the following parts directly to hot air or flame; 2 B 3 B A 7 A 8 D 1 D 1 B 2 B 1 E 4 E 2 Y-B 1 P- P+ Front Seat Outer Belt Assembly LH P6 PL- Y-B Curtain Shield Airbag Assembly LH 2 PL+ 2 Y PR+ G1(A),G2(B) PR- Front Seat Outer Belt Assembly RH Q4 1 Instrument Panel Passenger Airbag Assembly A (IG) P2+ 8 ICL- 1 A 2 A 1 B 2 B 2A 10A IGN 2 B 4 1 Y IG2 H84(A),P1(B),Q1(C),P29(D),Q26(E) Y 2 Y-B ICL+ ICL- P13 1 21 Airbag Sensor Assembly A 2A 24 2B 6 25 A 26 A E1 E2 W-B W-B W-B Driver Side Squib Circuit (Horn Button Assembly) z2(D),z3(E) 5 A Y-R 6 A D+ Y-G D- Y-B Y-G Y Y-R P2- A D+ 3 D- D2+ D2- Y-R Y-G D2+ D2- 4 P2- P2+ A P+ 3 2 Y-B Y Y Y-B P- A 1 L+ L- R+ R- ICL+ B 2 D 5 B 1 D 6 C 4 E 4 C 5 E 3 B 7 D 4 (*3) B 6 (*2) D 3 Spiral Cable Sub-Assembly H31(B),z2(D),z3(E) 2A 25 2B 4 W-B Pretensioner Pretensioner 1 Q9 ICR- ICR+ Y-B 2 SFR+ SFR- 19 A 20 A Y-B Y Lower No. 2 Instrument Panel Airbag Assembly H12 1 PK+ PK- 2 PK+ Y 1 2 SFL- 2 Y-B Curtain Shield Airbag Assembly RH P2 Front Seat Airbag Assembly LH Q2 Front Seat Airbag Assembly RH 1 SFR- SFR+ SFL+ SFL+ Y Y-B Y SFL- ICR+ ICR- GSW Telematics Transceiver H145(A) 24 A (*3) C 6 (*2) E 7 C 7 E 8 B 10 D 2 B 9 D 1 C 10 E 6 C 9 E PK- 14 A 2A 45 2A 39 GSW2 B B 9 A 10 A Y-B Y Lower No. 1 Instrument Panel Airbag Assembly H32(A),H139(B) DK+ DK- DK+ DK- GSW 18 A G Airbag Sensor Assembly H84(A),P1(B),Q1(C),P29(D),Q26(E) GSW 24 Main Body ECU 2A 47 ABFS 29 C 1 B 1 A (RHD) 2 B (LHD) 2 A * 2 :w/ Rear Pretensioner * 4 :w/ Telematics System * 3 :w/o Rear Pretensioner LG R GSW3 38 2A 46 2A A 24 5 Power Management Control ECU H3(C),H4(D) CA1H CA1L 24 D 25 D V (LHD) V (RHD) P (RHD) P (LHD) BCL+ 2 A7 Front Airbag Sensor LH LSP- LSP+ LBE+ LBE- 4 3 2 1 Front Seat Inner Belt Assembly LH P3 R G G V LSP+ LBE+ LSP- Seat Position Airbag Sensor LBE- Buckle Switch +SR 2 1 BCL- 2 1 R BCL- P7 Front Side Airbag Sensor Assembly LH 3 R 4 BBL+ BBL- BBL- BBL+ G G BCL+ W W -SL +SL -SR 2 1 B B W Front Airbag Sensor RH 2 A44 1 +SL -SL 1 B B W 2 1 +SR -SR BCR+ 2 1 BCR- 2 1 R BCR- Q5 Front Side Airbag Sensor Assembly RH 3 R 4 BBR+ BBR- BBR- BBR+ G G BCR+ (*4) (*4) 30 A 28 A 29 A 27 A Airbag Sensor Assembly H84(A),P1(B),Q1(C),P29(D),Q26(E) Rear Side Airbag Sensor Assembly RH Q6 Rear Side Airbag Sensor Assembly LH P10 PMC+ 2 1 PMC- Airbag Cut Off Switch Cylinder Sub-Assembly H134 11 A 12 A MSW+ MSW- Y (*1) B (*1) C 12 C 13 C 15 Seat Position Airbag Sensor RSP- RBE+ RSP+ G W-B R Q19 Front Seat Inner Belt Assembly RH 2 3 4 RBE+ RSP+ RSP- (RHD) (RHD) (LHD) (LHD) (LHD) (LHD) * 1 :w/ Airbag Cut Off Switch * 2 :w/ Rear Pretensioner * 3 :w/o Rear Pretensioner B 8 D 24 B 15 D 23 C 8 E 17 (*3) C 11 (*2) E 18 (*3) B 12 (*2) D 18 B 11 D 10 B 13 D 17 B 14 D 9 V(RHD) V(RHD) P(RHD) P(RHD) V(LHD) V(LHD) P(LHD) P(LHD) P-AB 20 B PASSENGER AIR BAG ON/OFF Indicator B 8 10A ECU-IG NO.2 (BAT) BE P-AB 2 2B B 17 A B 1 83 73 Junction Connector H118 13 9 4 5 6 5 B 11 B 6 B 12 B CANH R (LHD) W (LHD) Junction Connector H113(B) C 14 Buckle Switch RBE- R 1 RBE- (RHD) (RHD) P (LHD) V (LHD) H84(A),P1(B),Q1(C),P29(D),Q26(E) Airbag Sensor Assembly 1 A 2 A 6 B 12 B 1 A 7 A 6 B 12 B 1 A 7 A R (LHD) W (LHD) R (RHD) W (RHD) Junction Connector A57(A),H112(B) Junction Connector A71(A),H141(B) (RHD) P (LHD) V (RHD) V (LHD) P CANL CANH 13 A 5 A Junction Connector H104(A),H105(B) ECM A60(A) RR+ RL+ Y 1 2 1 Q27 Rear Seat Outer Belt Assembly RH PRR- E PRR+ Y 2 E 1 8 D D 7 PLR+ 2 Y-B PLR- P30 Rear Seat Outer Belt Assembly LH Y-B Pretensioner Pretensioner RR- RL- (*2) (*2) (*2) (*2) (*1) (*1) (*1) (*1) 10 B 4 B 10 B 4 B P (LHD) V (LHD) P (RHD) V (RHD) V(RHD) V(RHD) P(RHD) P(RHD) V(LHD) V(LHD) P(LHD) P(LHD) PAON 19 R PAON H72 Combination Switch Assembly 23 A R 2 37 33 18 38 EP W-B 22 7.5A MET 2A 44 (IG) 7.5A ECU-B 1 2 (BAT) BR IG2 B CANH CANL 31 32 21 B V 7 2D 18 2C SRS Driver H117 Junction Connector W-B W-B 36 57 Junction Connector H119 E2 9 W-B W-B P V 22 A A B 8 B A 5 A B 11 B B 12 B CANL R (RHD) W (RHD) Junction Connector H142(B) (RHD) V (RHD) P(LHD) P(RHD) V(RHD) V(LHD) P(LHD) P(RHD) V(RHD) V(LHD) V P L B P (RHD) (RHD) (LHD) (LHD) H118 Junction Connector 49 40 50 W-B (LHD) (RHD) (*1) (*1) * 5 :Before Aug. 2014 Production * 6 :From Aug. 2014 Production * 7 :LHD Europe, RHD * 8 :LHD Except Europe B (BAT) 2 5 7.5A ECU-B NO.4 (*6 *7) 42 B (*6 *7) 20 2A (*5,*6 *8) Combination Meter Assembly H19
Электрические цепи подушек безопасности защищены предохранителем IGN на 10 Ампер (красный) . На этом автомобиле система SRS AirBag имеет коммуникацию по CAN-BUS.
В данной схеме рассмотрены модификации: c выключателем подушки безопасности пассажира и без (OPS-Lexus) с преднатяжителями задних ремней и без с системой телематики и без с задними боковыми подушками и без с левым и правым рулём