Схема SRS AirBag Lexus IS200T,IS250,IS300,IS350 [Европа] 2013 год
Instrument Panel Passenger Airbag without Door Assembly Spiral Cable with Sensor Sub-Assembly , Driver Side Squib Circuit (Horn Button Assembly) Spiral Cable with Sensor Sub-Assembly , Driver Side Squib Circuit (Horn Button Assembly) Airbag Sensor Assembly Rear Seat Airbag Assembly RH (Rear Side Seat Back Assembly RH) Rear Seat Airbag Assembly LH (Rear Side Seat Back Assembly LH) Lower No. 2 Instrument Panel Airbag Assembly Lower No. 1 Instrument Panel Airbag Assembly Curtain Shield Airbag Assembly RH Curtain Shield Airbag Assembly LH Front Airbag Sensor RH Front Airbag Sensor LH Front Seat Outer Belt Assembly RH Front Seat Outer Belt Assembly LH Rear Airbag Sensor LH Pop Up Hood Lifter Assembly LH Rear Airbag Sensor RH Pedestrian Protection Sensor LH Side Airbag Sensor Assembly LH Side Airbag Sensor Assembly RH Rear Seat 3 Point Type Outer Belt assembly LH Airbag Cut Off Switch Cylinder Sub-Assembly Rear Seat 3 Point Type Outer Belt Assembly RH Combination Meter Assembly Telematics Transceiver A/C Control Assembly Front Seat Airbag Assembly LH Front Seat Inner Belt Assembly RH Pop Up Hood Lifter Assembly RH Pedestrian Protection Sensor RH ECM No. 1 CAN Junction Connector No. 2 CAN Junction Connector Front Seat Airbag Assembly LH Front Seat Airbag Assembly RH Engine Stop and Start ECU d=" M 1087.82, 273.74 L 1087.82, 341.16
d=" M 1087.82, 258.73 L 1087.82, 180.26
d=" M 1172.80, 511.70 L 1172.80, 579.69
d=" M 1189.80, 273.74 L 1189.80, 341.16
d=" M 1189.80, 258.73 L 1189.80, 180.26
d=" M 1283.29, 511.70 L 1283.29, 579.69
d=" M 2362.61, 477.71 L 2362.61, 537.20
d=" M 2362.61, 410.28 L 2362.61, 462.69
d=" M 2422.10, 341.16 L 2422.10, 282.24
d=" M 2422.10, 231.25 L 2422.10, 189.32
KY1 KY1 KY1 KY1 KA3 KA3 KA6 KA6 AQ4 AQ4 AQ4 AQ4 Po1 Po1 Qp1 Qp1 AP2 AP2 AP2 AP2 KA2 KA2 KB KC KC * * * If the following parts have been dropped, or have cracks, dents and other defects in their case, bracket, and connector, replace with new one. For the purpose of reuse, never disassemble and repair the following parts. Even in cases of a minor collision where the SRS does not deploy, the following parts should be inspected; * Never use SRS parts from another vehicle. When replacing parts, replace with new parts. If the vehicle is equipped with a mobile communication system, refer to the precaution in the IN section of the Repair Manual. After work on the SRS is completed, check the SRS warning light. Information labels are attached to the periphery of the SRS components. Follow the instructions of the notice. * Use a volt/ohmmeter with high impedance (10 kΩ/V minimum) for troubleshooting electrical circuits of the system. However, it is not possible to make a record of these memory contents. So when the work is finished, it will be necessary to explain it to your customer, and ask the customer to adjust the features and reset the memory. * * * Work must be started more than 90 seconds after the engine switch is pushed to the "OFF" position and the negative (-) terminal cable is disconnected from the battery. When the negative (-) terminal cable is disconnected from the battery, the memory of the clock and audio system will be cleared. So before starting work, make a record of the contents in the audio memory system. When work is finished, reset the audio systems as they were before and adjust the clock. Some vehicles have power tilt steering, power telescopic steering, power seat and power outside rear view mirror which are all equipped with memory function. * Before repair, remove the airbag sensor if shocks are likely to be applied to the sensor during repair. NOTICE : When inspecting or repairing the SRS, perform service in accordance with the following precautionary instructions and the procedure, and precautions in the Repair Manual applicable for the model year. Malfunction symptoms of the SRS are difficult to confirm, so the DTCs become the most important source of information when troubleshooting. When troubleshooting the SRS, always inspect the DTCs before disconnecting the battery. * * * (The SRS is equipped with a back-up power source so that if work is started within 90 seconds from disconnecting the negative (-) terminal cable of the battery, the SRS may deploy.) To avoid erasing the memory in each system, never use a back-up power supply from outside the vehicle. * Do not expose the following parts directly to hot air or flame; * Side airbag assembly * Steering wheel pad * Front passenger airbag assembly * Curtain shield airbag assembly * Knee airbag assembly * Seat belt pretensioner * Center airbag sensor assembly * Front airbag sensor assembly * Door side airbag sensor assembly * Side airbag sensor assembly * Rear airbag sensor assembly * Pop up hood lifter assembly * Pedestrian protection sensor * Rear seat airbag assmbly Y Y-B Y-G Y-R Y Y-B Y-G Y-R Y Y-B Y Y-R Y-G B Y-B BR BR Y-B Y Y-B Y Y Y-B (*1) (*1) (*1) BR BR P+ P- P2+ P2- 2 B 1 B 2 A 1 A Y1(A),Y2(B) Instrument Panel Passenger Airbag without Door Assembly 1 B 2 C C 1 B 2 z2(B),z3(C) Driver Side Squib Circuit (Horn Button Assembly) D+ D- D2+ D2- 3 A 1 A 2 A 4 A Spiral Cable with Sensor Sub-Assembly K31(A),z2(B),z3(C) 10 A DK- 7 A D2- 19 A PK+ 20 A PK- 4 A P+ 16 B SRR+ 3 A P- 15 B SRR- 25 A E1 1 A P2+ 2 A P2- 9 C SRL+ 10 SRL- 21 A IG2 26 A E2 5 A D+ 9 A DK+ 6 A D- 8 A D2+ K51(A),P31(B),Q9(C) Airbag Sensor Assembly 2 SRR+ 1 SRR- P12 Rear Seat Airbag Assembly RH (Rear Side Seat Back Assembly RH) 2 SRL+ 1 SRL- Q21 Rear Seat Airbag Assembly LH (Rear Side Seat Back Assembly LH) Knee Airbag PK+ PK- 1 2 Lower No. 2 Instrument Panel Airbag Assembly K53 Knee Airbag DK+ DK- 2 1 Lower No. 1 Instrument Panel Airbag Assembly K48 7.5A A/BAG-IG2 4A 8 2 (IG) 4A 47 4A 9 4A 45 4A 37 1 2 3 4 Y-B Y Y Y-B W B W B W B W B Y-B Y B Y R W B Y R W Y Y-B (*1) K51(A),P31(B),Q9(C) Airbag Sensor Assembly C 30 A +SL 28 A -SL 24 B BBR+ 23 B BBR- 29 A +SR 27 A -SR 17 C BBL+ 18 C BBL- 5 C ICL+ 4 C PL+ 6 C ICL- 3 C PL- 4 B ICR+ 5 B PR+ 3 B ICR- 6 B PR- 1 ICR+ 2 ICR- Curtain Shield Airbag Assembly RH P15 1 ICL+ 2 ICL- Q24 Curtain Shield Airbag Assembly LH 2 +SR 1 -SR Front Airbag Sensor RH A8 2 +SL 1 -SL Front Airbag Sensor LH A43 R+ R- Pretensioner 1 2 P10 Front Seat Outer Belt Assembly RH Pretensioner L- L+ 1 2 Q19 Front Seat Outer Belt Assembly LH 1 BBL+ 4 BCL+ 2 BBL- 3 BCL- Q22 Rear Airbag Sensor LH 1 BBR+ 4 BCR+ 2 BBR- 3 BCR- P13 Rear Airbag Sensor RH 2 BBL+ 1 BBL- Side Airbag Sensor Assembly LH Q18 2 BBR+ 1 BBR- Side Airbag Sensor Assembly RH P9 1 2 1 2 * 1 :w/ Rear Side Airbag Y-B Y L G Y-B Y (LHD) Y-B Y Y-B Y Y-B (LHD) (LHD) (LHD) LG R LG R G L G L (*5) (*5) (*5) (*5) Y Y-B Y K51(A),P31(B),Q9(C) Airbag Sensor Assembly 1 C PLR+ 12 C PUL+ 2 C PLR- 11 C PUL- 8 B PRR+ 20 C PSL+ 7 B PRR- 19 C PSL- 16 C LSP+ 1 B SFR+ 2 B SFR- 24 C LSP- 15 C LBE+ 8 C SFL+ 23 C LBE- 7 SFL- 2 PLL+ 1 PLL- A45 Pop Up Hood Lifter Assembly LH 2 PSL+ 1 PSL- Pedestrian Protection Sensor LH A44 RL- RL+ Pretensioner 1 2 Q23 Rear Seat 3 Point Type Outer Belt assembly LH RR- Pretensioner RR+ 1 2 P14 Rear Seat 3 Point Type Outer Belt Assembly RH LBE+ LBE- Buckle Switch Seat Position Airbag Sensor LSP+ LSP- 4 3 2 1 Front Seat Airbag Assembly LH Q13 SFL+ SFL- 1 2 Front Seat Airbag Assembly LH p1 SFR+ SFR- 1 2 o1 Front Seat Airbag Assembly RH 2 3 1 4 1 2 1 2 Y W B W G B Y-B B (*3) (*3) (*2) (*2) (*2) (*2) B Y-B R G Y-B Y (RHD) (RHD) (RHD) (RHD) (*4) (*4) (RHD) BE BE L B W L B W Y-B K51(A),P31(B),Q9(C) Airbag Sensor Assembly 13 A CANH C 11 A MSW+ 9 B RSP+ 12 A MSW- 17 B RSP- 17 A P-AB 10 B RBE+ 18 B RBE- 23 A PAON 13 B PUR+ 18 A GSW 14 B PUR- 24 A GSW3 21 B PSR+ 22 2 PMC+ 1 PMC- Airbag Cut Off Switch Cylinder Sub-Assembly K98 24 A GSW K66(A) Telematics Transceiver P-AB PAON PASSENGER AIRBAG ON/OFF Indicator 12 13 A/C Control Assembly K65 Main Body ECU GSW RBE+ RBE- Buckle Switch Seat Position Airbag Sensor RSP+ RSP- 4 3 2 1 P4 Front Seat Inner Belt Assembly RH 2 PLR+ 1 PLR- A10 Pop Up Hood Lifter Assembly RH 2 PSR+ A9 Pedestrian Protection Sensor RH 24 7 4A 17 4A 25 4A 48 4A 46 4A 38 4A 26 4A 2 3 1 4 * 4 :w/ Airbag Cut Off Switch * 2 :w/ PASSENGER AIRBAG ON/OFF Indicator * 5 :w/ Rear Pretensioner * 3 :w/ Telematics Transceiver B R B L LG B B R (RHD) B (LHD) B (LHD) (RHD) B (RHD) BE (LHD) BE (LHD) B G G B (LHD) B (RHD) BE (LHD) BE (RHD) B (LHD) B (RHD) BE (LHD) BE (RHD) 22 A CANL B PSR- 5V IC Telltales LED Driver CAN I/F ES CANL CANH B IG+ CPU CPU 5V+B 30 A 29 A 21 A 22 A 31 A Combination Meter Assembly K3(A) 1 PSR- 13 26 26 A B C CANL 13 14 13 B A C CANH A77(B),A91(A),A108(C) ECM 4 14 11 12 1 2 No. 1 CAN Junction Connector K109 11 1 15 5 3 13 No. 2 CAN Junction Connector K110 7 20 (*6) (*7) (*10) *10 :2GR-FKS * 8 :w/ Stop & Start System * 7 :8AR-FTS * 9 :w/o Stop & Start System * 6 :2GR-FSE, 4GR-FSE K3(A) Combination Meter Assembly LG LG LG B BR BR GR (*8) (*9) (BAT) 2 1 10A MPX-B NO.1 10 C IG12 Engine Stop and Start ECU K139(C) 4C 32 4B 30 7.5A METER 2 (IG) 4A 53
Электрические цепи подушек безопасности защищены предохранителем IG2 на 10 Ампер (красный) , Машины с двигателями 2GR-FSE 4GR-FSE.. На этом автомобиле система SRS AirBag имеет коммуникацию по CAN-BUS.
В данной схеме рассмотрены модификации: c выключателем подушки безопасности пассажира и без (OPS-Lexus) с преднатяжителями задних ремней и без с системой телематики и без с индикатором PASSENGER AIRBAG ON OFF и без с задними боковыми подушками и без с системой старт стоп и без с левым и правым рулём